Product ID:MULTIPURPOSE ATF,03950
MSDS Date:08/04/1992
FSC:9150
NIIN:00-698-2382
MSDS Number: BTHHN

UNION OIL CO OF CALIFORNIA UNOCAL CHEMICALS DIV

1201 W 5TH ST
LOS ANGELES, CA 90017
US

Emergency Phone: 213-977-7589/800-424-9300(CHEMTREC)

Info Phone: 213-977-7589/5227

Cage: 23034

76 PRODUCTS CO

LOS ANGELES, CA 90017 US

Telephone: 213-977-7589

Cage: 23034

MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')

CAS: 8012-95-1

RTECS: PY8030000

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3 (MIST); 9394

DISTILLATES, SOLVENT-DEWAXED LIGHT PARAFFINIC

CAS: 64742-56-9

RTECS: PY8039500

Fraction By Weight: 0 - 59%

OSHA PEL 5 MG/M3 (OIL MIST).

ACGIH TLV: 5 MG/M3 (OIL MIST).

MINERAL OIL/SOLVENT-DEWAXED HEAVY PARAFINIC PETROLEUM

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 0 - 30%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
TRACT. ACUTE- MAY CAUSE EYE/SKIN IRRITATION. PROLONGED/REPEATED
SKIN CONTACT MAY CAUSE BURNING, DRYING & CRACKING. INHALATION OF
VAPORS/OIL MIST MAY BE IRRITATING TO UPPER RESPIRATORY TRACT.
INGESTION OF EXCESSIVE QUANTITIES MAY CAUSE DIGESTIVE TRACT
IRRITATION. CHRONIC- UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES, SKIN, RESPIRATORY AND DIGESTIVE TRACTS
IRRITATION, SKIN BURNING AND DRYING, TEARING, REDNESS OF EYES
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED RESPIRATORY FUNCTION MAY BE
MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT.

First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:FLUSH WITH WATER FOR
15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WIPE EXCESS. WASH SKIN WITH
SOAP & WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF
NEEDED. ORAL:CALL A PHYSICIAN. IF VICTIM IS DROWSY OR UNCONSCIOUS,
PLACE ON THE LEFT SIDE WITH THE HEAD DOWN. DO NOT GIVE ANYTHING BY
MOUTH. IF POSSIBEL, DO NOT LEAVE VICTIM UNATTENDED.

Flash Point Method:COC
Flash Point:=160.C, 320.F
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, HALON, FOAM/WATER
SPRAY IS RECOMMENDED. WATER SPRAY MAY BE USED TO DISPERSE VAPORS.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND
NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:MAY BURN BUT NOT READILY. CONTAINER MAY
EXPLODE IF NOT COOLED PROPERLY. VAPORS ARE HEAVIER THAN AIR AND MAY
ACCUMULATE IN LOW AREAS.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. STOP LEAK. DIKE
SPILLS. USE PUMP TO TRANSFER SPILLS TO CONTAINER FOR DISPOSAL.
REMAINING LIQUID/SMALL SPILLS CAN BE TAKEN UP ON SAND, CLAY, EARTH
& SHOVELD INTO CONTAINE RS. PREVENT RUN-OFF TO ENTER WATERWAYS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY, VENTILATED PLACE
AWAY FROM EXCESSIVE HEAT, FLAMES & STRONG OXIDIZERS.
Other Precautions:AVOID CONTACT WITH SKIN, EYES, AND CLOTHING. WASH
THOROUGHLY AFTER HANDLING. LAUNDER CLOTHING BEFORE REUSE. AVOID
INHALING MISTS. EMPTY CONTAINERS OF THIS PRODUCT MAY BE HAZARDOUS
DUE TO THE RETENTION OF RESIDUES.

Respiratory Protection:NONE. IF TLV EXCEED, WEAR A NIOSH-APPROVED SELF
CONTAINED BREATHING APPARATUS.
Ventilation:LOCAL EXHAUST FAN IS RECOMMENDED TO MAINTAIN CONCENTRATION
OF OIL MIST IN AIR BELOW RECOMMENDED TLV.
Protective Gloves:RUBBER/OIL RESISTANT GLOVES RECOMMENDED
Eye Protection:SAFETY GOGGLES/FACE SHIELD IF NEEDED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
FORMULA CHANGED. FOR PREVIOUS FORMULATION, SEE PNI A UNDER THE SAME
NSN. NOTE TO PHYSICIAN:ACUTE ASPIRATION OF LARGE AMOUNTS OF OIL MAY
CAUSE A SERIOUS ASPIRATION PNEUMONIA. REPEATED ASPIRATION OF SMA LL
QUANTITIES OF MINERAL OIL CAN PRODUCE CHRONIC INFLAMMATION OF THE
LUNGS.

HCC:V6
Boiling Pt:>271.1C, 520.F
Vapor Density:>1
Spec Gravity:0.88
Viscosity:36-38 CS@104F
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, RED LIQUID - CHARACTERISTIC PETROLEUM ODOR
Percent Volatiles by Volume:NEGLIG

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTENDED EXPOSURE TO HIGH TEMPERATURES MAY
CAUSE DECOMPOSITION.
Hazardous Decomposition Products:COMBUSTION MAY YIELD MAJOR AMOUNTS OF
CARBON AND MINOR AMOUNTS OF OXIDES OF NITROGEN, PHOSPHORUS AND
SULFUR.

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. THIS
PRODUCT IS AN OIL. SPILLS INTO OR LEADING TO SURFACE WATERS THAT
CAUSE A SHEEN MUST BE REPO RTED TO NATIONAL RESPONSE CENTER,
800-424-8802.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.